...Opel 1.6 Lt. with multec system Checking the coolant temperature sensor (CTS). If the CTS, in this system, is checked with an oscilloscope, a voltage pattern is shown that under circumstances can lead to a wrong diagnosis ( see picture below). When the engine is started and col...
...MINI R50 / R52 / R53 (Cooper S) With manual air conditioning system Temperature regulation not possible Problem: Adjusting the temperature via the control element is no longer possible. Possible cause: The mixed air flap lever comes loose from the flap shaft. Solution of the proble...
...Ford Transit 2.0 Model year: 2001 – 2005 Engine code: D2FA with VP30 injection pump Engine cuts out In the above vehicles, the engine may cut out after briefly stepping on the accelerator pedal or running over a pothole. What is striking here is that when the error occurs while r...
...Brake disk General information Since the introduction of the disk braking system to the automobile, it has become a key structural component in automotive engineering. Together with the brake lining, the brake disk forms a friction couple which is subject to wear and tear and must be...
...Renault Clio 2 All vehicles with fog lights Water in the fog lights If there are complaints about the above-mentioned f ault, the cause could be the cable seal of the fog lights. In this event, a conversion set consisting of a modified cable loom + two protection caps is available f...
...Opel Vectra C and Signum Model year 2004 Starter not working If there are complaints about the above-mentioned fault, the cause could be a defective fuse. A short-circuit between terminal 50 and the heat shield occurs due to an incorrectly fitted cable lug (twisted 180°). Fuse F 2 the...
...Ford Fiesta model year 1998–2001 Fiesta model year 2002–2005 Focus model year 1999–2005 Speedometer fluctuates, engine starts poorly, volume of speed- dependent radio becomes quieter. If there are complaints with these vehicles about th e above-mentioned faults, one possible...
...Opel Vauxhall Meriva B Model year: 2010–2011 Chassis no.: A4000001 – B4231542 Engine does not start. If the engine of the vehicle listed above does not start, the cause may be a defective power steering hydraulic pump. To find the source of the fault in this case, the power ste...
...Mitsubishi Galant VI (EA) Model year: 09.96–05.01 Engine overheated / Coolant level too low / Noises / Heating performance If, in the case of the above-mentioned vehicles, the engine overheats, or the coolant temperature rises too high, this may be related to the hose in the coolant e...
...Subaru Trezia Model year: 2011 Failure of the power steering. Failure of the power steering may occur in the vehicles listed above. The cause may be a defective relay in the power steering control unit. During production of the control unit, it is possible that moisture entered a rel...