132 results found for LuK

• 
• Type

  Tech Tip

• LuK Clutch Academy - 2009 Audi Quattro 2.0TDi

• Nov 20

• LuK (132) Contact
• 

...LuK Clutch Academy 2009 Audi 2.0 TDI Quattro This month, REPXPERT Alistair Mason, replaced the clutch assembly and dual mass flywheel (DMF) on a 2009 Audi TT 2.0 TDi Quattro, which had covered more than 85,000 miles. With a recommended book time of seven hours and all information availabl...

• 
• Type

  Tech Tip

• LuK Clutch Academy - 2013 Opel Movano 2.3D

• Sep 20

• LuK (132) Contact
• 

...REPXPERT Alistair Mason, replaces the clutch on a Opel Movano 2.3 D, which had covered more than 140,000 miles. As is the norm with light commercial vehicles, the first job is to check the ramp's weight capability and how much equipment is in the back of the vehicle. The Movano has an '...

• 
• Type

  Technical Bulletin

• DMF - Important things to consider before installation

• Sep 20

• LuK (132) Contact
• 

...Dual mass flywheel Dual mass fly wheel DMF - Important things to consider before installationIt's all in the preparation! Ralf Kuhlmey, Technical Trainer at Schaeffler in the Automotive Aftermarket, shows how to properly prepare for a professional DMF replacement…...

• 
• Type

  Technical Bulletin

• DMF - Visual inspection and damage patterns

• Sep 20

• LuK (132) Contact
• 

...DMF - Visual inspection and damage patterns Dual mass flywheel Dual mass fly wheel Ralf Kuhlmey, Technical Trainer at Schaeffler in the Automotive Aftermarket, conducts a visual check of several LuK DMFs - highlighting the different types of issues that can occur – such as greas...

• 
• Type

  Technical Bulletin

• DMF Testing Tool

• Sep 20

• LuK (132) Contact
• 

...DMF Testing Tool Dual mass flywheel Dual mass fly wheel Using the LuK DMF Testing Tool allows you to determine possible DMF wear by measuring the rotational freeplay angle and the bearing rock. Ralf Kuhlmey, Technical Trainer at Schaeffler in the Automotive Aftermarket, explains how to...

• 
• Type

  Tech Tip

• LuK Clutch Academy - Skoda Rapid 1.6 TDi

• Sep 20

• LuK (132) Contact
• 

...See this and 1,000s more Tech Tips on TechTips.ie 48 August/September 2020 AUTOBIZ See this and 1,000s more Tech Tips on TechTips.ie Gearbox removal With the vehicle positioned on a vehicle lift – either a two-post or wheel-free is ideal – open the bonnet, disconnect the ai...

• 
• Type

  Tech Tip

• LuK Clutch Academy Nissan Qashqai 1.5 dCi

• Jun 20

• LuK (132) Contact
• 

...LuK Clutch Academy Nissan Qashqai 1.5 dCi This month, REPXPERT, Alistair Mason, replaced the clutch assembly in a 2014 2WD Nissan Qashqai. The repair time is four-and-a-half hours, with the following workshop equipment required: two-post vehicle lift, engine support, transmission jack...

• 
• Type

  Tech Tip

• LuK Clutch Academy Ford Transit 2.2 TDCi FWD

• Feb 20

• LuK (132) Contact
• 

...LuK Clutch Academy Ford Transit 2.2 TDCi FWD This month, REPXPERT Alistair Mason replaced the clutch on a 2011 Ford Transit 2.2 TDCI front-wheel drive, which had covered more than 130,000 miles. The repair time is just over three-and-three-quarter hours and requires a wheel-free vehicle...

• 
• Type

  Tech Tip

• LuK Clutch Academy Audi A1 1.6TDi

• Jan 20

• LuK (132) Contact
• 

...LuK Clutch Academy Audi A1 1.6TDi This month, REPXPERT Alistair Mason, replaces the clutch on a 2016 Audi A1, fitted with a 1.6 TDi. With a repair time of just five hours and a requirement for only minimal workshop equipment – a two-post lift, engine support, transmission jack, clutch a...

• 
• Type

  Tech Tip

• LuK Clutch Academy Peugeot 206 1.1P

• Nov 19

• LuK (132) Contact
• 

...LuK Clutch Academy Peugeot 206 1.1P This month, Alistair Mason, inspects a 2005 1.1 petrol Peugeot 206, which had covered more than 75,000 miles. It was difficult to get the vehicle into gear, as the clutch was not fully disengaging and there was a 'scrapping' noise emanating from the bel...