4511 results

• 
• Type

  Technical Bulletin

• PSA 1.9, 2.0 & 2.2D Tensioner Differences

• Jan 14

• Gates (127) Contact
• 

...Despite a difference between the design of the OE tensioner and the Gates tensioner, (Fig.1) they do the same job. However, there is a different installation procedure. In the withdrawn position, the OE tensioner can be locked using a pin. The new belt is installed over the (top) idler. T...

• 
• Type

  Tech Tip

• Focus C-Max 1.6 Ti timing belt fitting guide

• Oct 15

• Contitech (157)
• 

...Focus C-Max 1.6 Ti timing belt fitting guide Significant errors are frequently committed when changing the timing belt on a Focus C-Max 1.6-liter Ti with engine code HXDA or SIDA. ContiTech experts provide a step-by-step explanation of the correct changing procedure to help you avoid any...

• 
• Type

  Tech Tip

• LuK Clutch Academy Kia Cee'd 1.6 CRDi

• Oct 15

• LuK (131) Contact
• 

...Kia Cee'd 1.6 CRDi LuK Clutch Academy The Kia Cee'd is a small family hatchback with various engine and body styles. Launched in 2006, it has become increasingly popular on Irish roads. LuK technical takes a closer look at a clutch replacement and offers some handy hints to garages lookin...

• 
• Type

  Tech Tip

• Sensing a commercial issue

• Oct 15

• Blue Print (202) Contact
• 

...Sensing a commercial issue An Isuzu N series fleet vehicle was giving trouble while being driven. The Isuzu 3 litre four-cylinder common rail engine was fitted with a 24V electrical system, which proves no problem to either G-Scan or G-Scan 2. Blue Print Technical Consultant Jim Gilmour e...

• 
• Type

  Technical Bulletin

• Opel Insignia - Driver Information Centre shows "Code 55" or "Check DPF"

• Sep 15

• Hella Ireland (1757)
• 

...Opel Insignia Model year: from 2009 onwards Engine code: A20DTC / A20DTH / A20DTJ Driver Information Centre shows "Code 55" or check "DPF" "Code 55" or check "DPF" appears in the Driver Information Centre. At the same time, noises originate from the exhaust gas system and the engine...

• 
• Type

  Technical Bulletin

• Opel Astra H - Headlamp replacement

• Sep 15

• Hella Ireland (1757)
• 

...2015 Opel Astra H From model year 2004 With dynamic bend lighting "Dynabeam" Replacement of the light source If the light source has to be replaced in the vehicle specified above, proceed as follows: disassemble the front apron of the vehicle and remove the headlamp. Then replace th...

• 
• Type

  Technical Bulletin

• Peugeot 307 HDI - Poor acceleration, Noise, Engine light on sporadically

• Sep 15

• Hella Ireland (1757)
• 

...Peugeot 307 HDI Engine code: 9HZ (DV6TED4) Model year: 2004 - 2005 Poor acceleration performance Noise in the vicinity of the splash wall Engine control lamp lights up sporadically Fault code: P0100, P3008 If the vehicle listed above demonstrates poor acceleration performance in c...

• 
• Type

  Technical Bulletin

• Chevrolet Volt - Auxiliary engine activated when battery dead (risk of intoxication)

• Sep 15

• Hella Ireland (1757)
• 

...Chevrolet Volt with range extender Model year: from 2010 onwards Auxiliary internal combustion engine activated when battery discharged (risk of intoxication) When an electric car is switched off, a warning sound informs the user if the system (electric motor) is still active. If th...

• 
• Type

  Technical Bulletin

• Hyundai Terracan - Limp-home mode, Air in cooling system

• Sep 15

• Hella Ireland (1757)
• 

...Hyundai Terracan Model year: 2001- 2006 Engine: 2.9 CRDi Engine goes into limp-home mode Air in the cooling system If the engine on the vehicles listed above enters limp-home mode, having a low coolant level or air in the cooling system is a potential cause. Symptom: While driving...

• 
• Type

  Service Information

• Brake pad wear indicator

• Oct 15

• Hella Ireland (1757)
• 

...Brake pad wear indicator Task The wear indicator is a monitoring device used to inform the driver promptly when the brake pad has reached its minimum thickness/wear limit. For disc brake pads, this is usually two millimeters. The wear indicator may be electronic or acoustic, depending...