...LuK clutch Academy Peugeot 308 2.0 HDi In this month’s Schaeffler LuK Clutch Academy, REPXPERT Bob Carter is replacing the clutch and dual mass flywheel (DMF) in a 2011 Peugeot 308 with a 2.0 HDi engine. The car has covered 115,306 miles and the driver has reported that selecting fir...
...LuK Clutch Academy Vivaro 2.5 DTi The Vivaro is a popular van, especially among tradesmen and fleet van operators. The platform for the Vivaro is also shared with Renault and Nissan, so the opportunity for clutch replacement is likely. The LuK technical team take a look at the clutch re...
...LuK Clutch Academy Nissan Juke 1.5 dCi Workshop equipment used Vehicle lift ñ (two post is ideal) Engine support Transmission jack Clutch alignment tool Note ñ Prior to the repair, ensure you have the locking wheel bolt key if required. Gearbox removal With the vehicle plac...
...LuK Clutch Academy - Mini One (R52) REPXPERT Alistair Mason, is replacing the clutch assembly in a 2008 Mini One (R52), that has covered more than 72,000 miles. The customer had reported that the clutch was “slipping” under load, and a short road test confirmed the clutch was at the e...
...LuK Clutch Academy - Mercedes C180 Kompressor The Mercedes C Class has been on our roads since 1993. In 2003, Mercedes introduced the C180 Sports Coupe range which has become a popular and desirable car. LuK offers advice on tackling this clutch replacement. The car featured is a 1.8...
...LuK Clutch Academy Juke 1.5 dCi REPXPERT Alistair Mason is replacing the clutch & dual mass flywheel (DMF) on a 2011 Nissan Juke 1.5 dCi, with a very heavy clutch pedal. After some initial diagnosis, gearbox removal was advised & authorization given. With a recommended repair time of 4...
...LuK Clutch Academy Iveco Daily pull type REPXPERT Alistair Mason is replacing the clutch in a 2014 Iveco Daily 35C17 that has covered 56,000 miles and had been recovered with no drive. The scheduled time for the repair is 4.20 hours and with no specialist equipment required, this makes a...
...LuK Clutch Academy Civic 2.2 CTDi REPXPERT Alistair Mason, is replacing the clutch & dual mass flywheel (DMF) on a 2007 Honda Civic 2.2 CTDi that has covered just under 73,000 miles. The vehicle has been booked in to investigate a rattle/knock from the engine & also clutch judder when pu...
...LuK Clutch Academy - Grand Vitara 1.6P G16B engine The LuK technical team takes a closer look at the Suzuki Grand Vitara, this one had covered close to 130,000 miles of harsh use through its service life. Because of this type of useage, it's important that particular attention is taken...
...LuK Clutch Academy Ford Transit II REPXPERT Alistair Mason is focusing on best practice clutch replacement to ensure an efficient and quality repair, using a front wheel drive 2012 Ford Transit fitted with a 2.2 TDCi engine as an example. Noticeably, there are more vans on the roads the...