4579 results

• 
• Type

  Tech Tip

• Luk Clutch Academy - Kia Ceed 1.4 CRDi

• Dec 22

• LuK (132) Contact
• 

...LuK Clutch Academy Kia Ceed 1.4 CRDi REPXPERT Alistair Mason is replacing the clutch assembly on a 2013 Kia Ceed, which has covered more than 106,000 miles, after clutch slip was diagnosed. With a recommended repair time of three-and-a-half hours and all repair instructions available th...

• 
• Type

  Technical Bulletin

• VAG Suspension Bushing Installation

• Nov 22

• Blue Print (208) Contact
• 

...febi 24390 SWAG 30 92 4390 To Fit: VW Beetle 2011- Passat 2005- Golf VII 2012- Touran 2006- Tiguan 2007- Audi A3 2003- TT 2006- Repl. No. 1K0 407 182...

• 
• Type

  Technical Bulletin

• VAG Suspension Bushing

• Nov 22

• Blue Print (208) Contact
• 

...VAG Suspension Bushing febi 24390 SWAG 30 92 4390 To Fit: VW Beetle 2011- Passat 2005- Golf VII 2012- Touran 2006- Tiguan 2007- Audi A3 2003- TT 2006- Repl. No. 1K0 407 182...

• 
• Type

  Technical Bulletin

• Rear wiper motor replacement - Audi A4 Avant

• Nov 22

• febi (174)
• 

...Audi A4 Avant Rear wiper motor replacement In this video, we test and replace the rear wiper motor on an Audi A4 Avant 8K model which was manufactured from 2007 - 2015. Common malfunctions of this part include the rear wiper not ‘parking’ in place and the rear washer failing t...

• 
• Type

  Component Description

• Exhaust gas cooler leaking: important installation notes

• Nov 22

• MAHLE (153)
• 

...When fitting a new EGR cooler on an engine, there are several essential steps to keep in mind. One of the most common mistakes is tightening the assembly screws of the EGR cooler entirely at random. To prevent exhaust gas coolers with flexible pipes from being under tension, make sure to t...

• 
• Type

  Technical Bulletin

• Installation note for piston pin circlips

• Nov 22

• MAHLE (153)
• 

...Installation note for piston pin circlips Various types of piston pin circlips are available, which are fitted in different ways. To protect piston pins against axial movement during operation, circlips are fitted in most combustion engines. In such cases, the piston pin still has lim...

• 
• Type

  Technical Bulletin

• Risk of confusion over air conditioning compressor safety valves

• Nov 22

• MAHLE (153)
• 

...Risk of confusion over air conditioning compressor safety valves Occasionally, when adjusting the oil quantity in a new air conditioning compressor, the safety valve is mistaken for the drain plug. If an air conditioning compressor is replaced, it’s almost always necessary to adjus...

• 
• Type

  Technical Bulletin

• Audi and Volkswagen V6 TDi intake manifold problems

• Nov 22

• febi (174)
• 

...Audi and Volkswagen V6 TDi ntake manifold problems Intake manifold with swirl flap actuator and gasket To fit: various Audi and Volkswagen models with the V6 TDi engine febi 176483,176525 Problem The engine performance and drivability is poor, and the engine warning lamp is...

• 
• Type

  Technical Bulletin

• Causes of overload protection tripping in air conditioning compressors

• Nov 22

• MAHLE (153)
• 

...Causes of overload protection tripping in air conditioning compressors When an A/C compressor's overload protection is triggered without any mechanical damage occurring, there are common suspects you should look for. In addition to severe speed fluctuations, excessive engine torque, o...

• 
• Type

  Technical Bulletin

• Mercedes Oil Filter Housing Cap with sealing ring Problem

• Nov 22

• Blue Print (208) Contact
• 

...Mercedes Oil Filter Housing Cap with sealing ring Problem Problem Whilst changing the engine oil filter during the service replacement process, the oil filter housing cap can break - leaving the oil filter alignment tube and element within the housing. (Fig.1) Cause After many hour...