4511 results

• 
• Type

  Technical Bulletin

• Water pump failure causing overheated engines

• Jan 23

• febi (170)
• 

...39304 Water pump failure causing overheated engines A recent febi ProTip described the overheating problems that can indicate a broken water pump impeller. The problem can be seen on various Citroen, DS, Fiat, Ford, Jaguar, Lancia, Land Rover, Mitsubishi, Opel, Peugeot and Toyota...

• 
• Type

  Technical Bulletin

• Toyota Suction Control Valve Problem

• May 23

• Blue Print (202) Contact
• 

...Blue Print ADT36853 to fit: Toyota Avensis, Corolla 2.0 D4d Toyota Suction Control Valve Problem Problem Engine surging, erratic idle, and a sudden lack of power which can be intermittent. Engine fault codes logged relating to fuel rail pressure deviation. Cause The Suc...

• 
• Type

  Technical Bulletin

• Adjustment cam on tensioner pulley fractures during tensioning

• May 23

• Contitech (157)
• 

...Adjustment cam on tensioner pulley fractures during tensioning process. Timing belt kits CT1168K1/ K2/ WP1/ WP2/ WP7/ WP9/ K6PRO/ WP8PRO VW, Audi, Seat, Skoda 1.4–2.0 TDI common rail, EA288 Problem: Adjustment cam on tensioner pulley fractures during tensioning process (Fig. A). Cau...

• 
• Type

  Technical Bulletin

• Noise from the timing belt drive

• May 23

• Contitech (157)
• 

...Noise from the timing belt drive, timing belt jumps or is torn, engine damage. Timing belt kits CT1168K1/K2/WP1/WP2/K6PRO/WP8PRO. VW, Audi, Seat, Skoda 1.4–2.0 TDI common rail, EA288 Problem: Noise from the timing belt drive, timing belt jumps or is torn, stop tab on tensioner pulley...

• 
• Type

  Technical Bulletin

• Tensioner pulley outer ring displaced

• May 23

• Contitech (157)
• 

...Tensioner pulley outer ring has become displaced. CT1078K1, CT1178K1 for Opel/Vauxhall/Chevrolet 1.7D/CDTI (A17 DT/DTC/DTE/DTF/DTI/DTJ/DTL/DTN/DTR/DTS, Z17 DT/DTH/DTL/DTJ/DTR, LKR, LUD) Problem: Noise from the timing belt drive. Misalignment in the belt drive. Timing belt jumps or is t...

• 
• Type

  Technical Bulletin

• Rear Brake Disc problem Peugeot, Citroen and DS

• May 23

• Blue Print (202) Contact
• 

...Rear Brake Disc with wheel bearing problem Various Peugeot, Citroën and DS models Many Peugeot, Citroën and DS models are equipped with rear brake discs that have an integrated wheel bearing. As a result, this type of assembly allows for significant weight saving, since the brake d...

• 
• Type

  Technical Bulletin

• Poor or erratic running Nissan petrol engines

• May 23

• febi (170)
• 

...to fit: Nissan Almera, Almera Tino, Expert, Micra, Note, Primera, Sunny, Wingroad 1.0, 1.2, 1.4, 1.5, 1.6, 1.8 Petrol engines Problem Incorrect camshaft and crankshaft synchronization, giving symptoms of poor acceleration and erratic engine rpm. The engine control unit may also...

• 
• Type

  Technical Bulletin

• Preventing exhaust gas cooler leaks

• Sep 22

• MAHLE (144)
• 

...Mahle Messenger Exhaust gas cooler leaking: important installation notes To avoid leaks and damage, a number of points must be observed when installing exhaust gas coolers. Exhaust gas coolers are installed in many modern engines. Their task is to cool the hot exhaust gases before t...

• 
• Type

  Technical Bulletin

• Installation note for piston pin circlips

• Nov 22

• MAHLE (144)
• 

...Installation note for piston pin circlips Various types of piston pin circlips are available, which are fitted in different ways. To protect piston pins against axial movement during operation, circlips are fitted in most combustion engines. In such cases, the piston pin still has lim...

• 
• Type

  Technical Bulletin

• Risk of confusion over air conditioning compressor safety valves

• Nov 22

• MAHLE (144)
• 

...Risk of confusion over air conditioning compressor safety valves Occasionally, when adjusting the oil quantity in a new air conditioning compressor, the safety valve is mistaken for the drain plug. If an air conditioning compressor is replaced, it’s almost always necessary to adjus...