...LuK Clutch Academy Vivaro 2.5 DTi The Vivaro is a popular van, especially among tradesmen and fleet van operators. The platform for the Vivaro is also shared with Renault and Nissan, so the opportunity for clutch replacement is likely. The LuK technical team take a look at the clutch re...
...LuK Clutch Academy Toyota RAV4 This Toyota Rav4, fitted with a 2.0 D4D, a Dual Mass Flywheel (DMF) and permanent four-wheel drive, had covered more than 130,000 miles. The customer reported that the clutch was slipping under full load, which was confirmed by a road test. Scheaffler's Ma...
...LuK Clutch Academy - Ford Focus 1.8 TDCi The Ford Focus is a popular car, so clutch replacement is a frequent undertaking. To ensure a quality repair inside the scheduled time of four and three-quarter hours, requires strict adherence to the correct procedure. Scheaffler's Malcolm Short...
...LuK Clutch Academy Opel Corsa 1.3 CDTi This month, Schaeffler REPXPERT Alistair Mason replaced the clutch and dual mass flywheel (DMF) on an Opel Corsa 1.3 CDTI, while also taking a close look at a modified concentric slave cylinder (CSC) replacement. With the vehicle positioned on the...
...LuK Clutch Academy Picanto 1.1 Petrol G4HG This month, REPXPERT's Alistair Mason replaces the clutch on a 2006 Kia Picanto, fitted with a 1.1 G4HG engine. For this type of repair, a two-post ramp, transmission jack and an engine support that locates on the front sub frame are required....
...Diagnosis in case of noises Replacement of the dual mass flywheel only after thorough inspectionIn the course of troubleshooting, the dual mass flywheel (DMF ) is often suspected of being defec-tive. Particular caution should be exercised here, because disturbing noises are often attri...
... SERVICE INFO LUK 0561 REPXPERT Hotline: +44 (0) 1432 264264 Fax : +44 (0) 1432 375 760 E-Mail: aftermarket.uk@schaeffler.com www.repxpert.co.uk For accurate model information please see the Schaeffler online catalogue Die genaue Fahrzeugzuordnung entnehmen Sie bit...
...Instructions for removing the 7-speed direct-shift gearbox 0AM with dry double clutchManufacturers: Audi, Seat, Škoda, VWModels: Audi: A3, A3 Cabriolet Seat: Altea, Ibiza, Leon, Toledo Škoda: Octavia, Superb VW: Golf, Golf Variant, TouranModel year: From 2008Engin...
...1. Operate the transmission until it is warmed up.2. With the clutch engaged and the trans-mission in neutral, increase the engine speed to approximately 4000 rpm.3. Step on the clutch pedal and shut the engine off at the same time.4. If you hear rattling noises which change as the speed...
...Flushing the Steering SystemIssued 11.2007 (replaces 11.2005)LuK 0002Technical subject to change© 2007 LuK-Aftermarket Service oHGAppropriate spare parts can befound in our on-line catalogue atwww.Schaeffler-Aftermarket.comor at www.RepXpert.com.Fine particles can enter the hydraulic syst...