...LuK Clutch Academy Volvo V50 This month, REPXPERT's Alistair Mason replaced the clutch on a 2010 Volvo V50, fitted with a 1.6TDi. The car had covered slightly less than 160,000 miles and reportedly suffered from the clutch 'slipping'. This engine is common between Volvo, Ford, Mini, Mazda...
...LuK Clutch Academy Peugeot 107 Semi-Auto This month, REPXPERT's Alistair Mason replaced the clutch on a semi-automatic Peugeot 107, which was fitted with a 1.0 litre 1KR engine, had covered just over 50,000 miles and reportedly suffered from clutch 'slipping'. Because these 'city' cars c...
...LuK Clutch Academy Toyota Yaris 1.3 This month, REPXPERT's Alistair Mason replaced the clutch on a 2014 Toyota Yaris, which was fitted with a 1.3 petrol engine. It had covered just over 80,000 miles and reportedly suffered from clutch 'slipping'. A short road test later confirmed that t...
...Bleeding process of CSC 510 0097 10 Modified hydraulic connectionManufacturer: Dacia Nissan RenaultFor current listing refer to parts catalogueThe hydraulic connection of concentric slave cylinder 510 0097 10 has been modified. It now corresponds to the configuration used in current veh...
...LuK Clutch Academy BMW Z4 This month, REPXPERT's Alistair Mason replaced the clutch on a 2007 BMW Z4. Launched in 2002, the Z4 has been fitted with various engine types – either 4 or 6 cylinder inline configurations – but has always been rear-wheel drive. Replacing the clutch, includ...
...LuK Clutch Academy Audi A3 1.6TDi REPXPERT's Alistair Mason replaced the clutch on a 2014 Audi A3 1.6TDI, using Schaeffler's LuK 2CT repair solution. This clutch replacement job can be completed in six-and-a-half hours. Following complaints that this Audi A3 1.6 TDi was juddering when pu...
...LuK Clutch Academy Freelander 2 TD4 REPXPERT's Alistair Mason replaced the clutch on a 2008 Land Rover Freelander 2 TD4, fitted with a 2.2 TDI engine. This clutch replacement job can be completed in 5 hours. With the vehicle positioned on the vehicle lift, open the bonnet, remove the b...
...LuK Clutch Academy Zafira 1.7 CDTi This month, REPXPERT's Alistair Mason replaced the clutch assembly in a 2013 Opel Zafira 1.7 CDTi, which had racked up more than 110,000 miles. As the clutch was slipping, combined with the heat generation and miles covered, the dual mass flywheel was al...
...LuK-Clutch-Academy-Fiat-500-Abarth REPXPERT's Alistair Mason replaced the clutch in a Fiat 500 Abarth. With the manufacturer recommending that the engine be removed first, Alistair decided that course was traumatic, and more pressingly, it was impossible! So he followed a more conventio...
...LuK Clutch Academy REPXPERT's Alistair Mason replaced the clutch and dual mass flywheel in a Peugeot 508 SW fitted with a 1.6 HDi engine, which had covered more than 170,000 miles. On initial inspection, the gearbox looked difficult to access and even harder to remove; however, by detach...