Search 4,514 docs, articles & videos from the world’s leading Automotive part manufacturers
3584 PDF Files Listed
-
-
Technical Bulletin
- Opel Astra H - Headlamp replacement
-
Sep 15
- Hella Ireland (1757)
-
...2015 Opel Astra H From model year 2004 With dynamic bend lighting "Dynabeam" Replacement of the light source If the light source has to be replaced in the vehicle specified above, proceed as follows: disassemble the front apron of the vehicle and remove the headlamp. Then replace th...
-
-
Technical Bulletin
- Belt Inspection Changes
-
Sep 15
- Gates (127) Contact
-
...AUTOMOTIVE PASSENGER CAR ACCESSORY BELT DRIVE SYSTEM Tech Tip Standard industry belt diagnostics call for replacement of a serpentine \ belt if it shows three cracks in a three inch section. This is a good rule of thumb for Neoprene, but not so good for EPDM. EPDM belts inherently resis...
-
-
Technical Bulletin
- Pulley Alignment & Tension
-
Sep 15
- Gates (127) Contact
-
...BULLETIN TT003-15› MAKE: All makes with a serpentine belt› MODEL: All models with a serpentine belt› YEAR: All years with a serpentine belt› ENGINE: All engines with a serpentine belt PULLEY ALIGNMENT & TENSIONToda...
-
-
Technical Bulletin
- Diagnosing Tensioner Failure
-
Sep 15
- Gates (127) Contact
-
...Unbeknownst to many, automatic belt tensioners are actually a wear item, and therefore cannot be classified as a prototypical hard part. Internal components in the tensioner can fail, causing stress on the belt and other accessory components. A tensioner is a relatively inexpensive part to...
-
-
Technical Bulletin
- Water Pump Failure Signs
-
Sep 15
- Gates (127) Contact
-
...If during the course of an inspection the water pump is found to look like any of the below, Gates recommends properly flushing the system, filling the system with a new mixture of the correct coolant, and possibly replacing the water pump depending on the issues found.BULLETIN TT005-15›...
-
-
Technical Bulletin
- Opel, Alfa, Fiat, Saab, Chevrolet 1.6/1.8 Tensioners
-
Sep 15
- Contitech (157)
-
...Timing belt kit CT 1077K1 for Opel, Alfa, Fiat, Saab, Chevrolet – various 1.6/1.8 models from 2003 ContiTech Power Transmission Group Philipsbornstrasse 1, D-30165 Hannover Tech. Hotline +49 (0)511 938 -5178 E-mail: frank.wissbroecker@ptg.contitech.de www.contitech.de/aam Th...
-
-
Technical Bulletin
- Peugeot 307 HDI - Poor acceleration, Noise, Engine light on sporadically
-
Sep 15
- Hella Ireland (1757)
-
...Peugeot 307 HDI Engine code: 9HZ (DV6TED4) Model year: 2004 - 2005 Poor acceleration performance Noise in the vicinity of the splash wall Engine control lamp lights up sporadically Fault code: P0100, P3008 If the vehicle listed above demonstrates poor acceleration performance in c...
-
-
Service Information
- Reconditioning plastic cover lenses
-
Sep 15
- Hella Ireland (1757)
-
...Plastic Cover Lenses for Headlamps Reconditioning plastic cover lenses Vehicle lighting makes a major contribution to keeping all road-users safe. Modern vehicle systems are becoming ever more complex, which is why headlamps used for vehicle lighting meet a wide variety of requirements. Wh...
-
-
Technical Bulletin
- Chevrolet Volt - Auxiliary engine activated when battery dead (risk of intoxication)
-
Sep 15
- Hella Ireland (1757)
-
...Chevrolet Volt with range extender Model year: from 2010 onwards Auxiliary internal combustion engine activated when battery discharged (risk of intoxication) When an electric car is switched off, a warning sound informs the user if the system (electric motor) is still active. If th...
-
-
Technical Bulletin
- Hyundai Terracan - Limp-home mode, Air in cooling system
-
Sep 15
- Hella Ireland (1757)
-
...Hyundai Terracan Model year: 2001- 2006 Engine: 2.9 CRDi Engine goes into limp-home mode Air in the cooling system If the engine on the vehicles listed above enters limp-home mode, having a low coolant level or air in the cooling system is a potential cause. Symptom: While driving...
