3584 PDF Files Listed

• 

• Tech Tip

• LuK Clutch Academy - 2009 Audi Quattro 2.0TDi

• Nov 20

• LuK (131) Contact
• 

...LuK Clutch Academy 2009 Audi 2.0 TDI Quattro This month, REPXPERT Alistair Mason, replaced the clutch assembly and dual mass flywheel (DMF) on a 2009 Audi TT 2.0 TDi Quattro, which had covered more than 85,000 miles. With a recommended book time of seven hours and all information availabl...

• 

• Technical Bulletin

• Tips for Low-Noise, Effective Braking

• Jan 21

• febi (170)
• 

...Tips for Low-Noise, Effective Braking ByMary VerDuin -15. October 2020The correct treatment of brake pads can prevent noise.Rattling, vibrations, squeaking: noises during braking ca n significantly impair the driving experience. But what exactly is behind these NVH phenomena and how can...

• 

• Technical Bulletin

• Replacing a switchable coolant pump

• Jan 21

• MAHLE (144)
• 

...Technical MessengerWhen replacing the coolant pump in EA 288-series 1.6 TDI and 2.0 TDI engines, various pump types can be installed. Starting in 2012, these engines were fitted with switchable coolant pumps during construction. To warm up the engine even faster, a shroud slides over the...

• 

• Technical Bulletin

• Fiat Brake Hose Problem

• Jan 21

• febi (170)
• 

...febi ProTip To fit: Fiat 500, 500C and Panda models Problem When the brake pedal is applied the pedal goes to the floor. The loss of pressure to apply the brakes results in brake failure. Cause The front flexible brake hose is prone to corrosion where the steel union connects to...

• 

• Technical Bulletin

• Ford heated windscreen and door mirrors issue

• Feb 21

• Autobiz (337)
• 

...Tales from the Helpline Tim Stock It is always this time of year that the Helpline is flooded with heating related issues, especially now that vehicles have been stood still for many months. This is one of those unusual problems that has many technicians confused. The complaint was...

• 

• Technical Bulletin

• Mini high and low oil pressure issues

• Feb 21

• Autobiz (337)
• 

...Tales from the Helpline Tim Stock Mini high and low oil pressure issues The Helpline continues to receive calls regarding the oil pressure control on engines fitted to both the Mini and PSA variants. These engines operate on a variable engine oil pressure control principle. This vari...

• 

• Technical Bulletin

• Porsche Cayenne - Steering fluid loss

• Feb 21

• Autobiz (337)
• 

...Tales from the Workshop Steve Rothwell Porsche Cayenne - Steering fluid loss The owner of this 2010 Porsche Cayenne V6 diesel had been seeing a few drips of oil under his parked vehicle from time to time. He believed he may have an engine oil leak, but had kept a keen eye on the dash...

• 

• Technical Bulletin

• Mercedes A-Class - Tricky access starter

• Feb 21

• Autobiz (337)
• 

...Tales from the Workshop Steve Rothwell Mercedes A-Class - Tricky access starter On 85% of vehicles, the starter motor is accessible. At the worst, it is a bit tricky to replace. The starter motor on the A-Class Mercedes is in a league of its own for difficulty. This 2001 A-Class...

• 

• Technical Bulletin

• VW Transporter - Driveshaft failure

• Feb 21

• Autobiz (337)
• 

...Tales from the Workshop Steve Rothwell VW Transporter - Driveshaft failure The driver of this 2009 VW Transporter had felt an unusual clunk from the driveline, but it had only happened the once, and he brushed it off as insignificant. When he felt the problem again accompanied...

• 

• Tech Tip

• LuK Clutch Academy - 2008 Ford Focus 1.6

• Feb 21

• LuK (131) Contact
• 

...LuK Clutch Academy 2008 Ford Focus 1.6 REPXPERT's Alistair Mason, replaces the clutch in a 2008 Ford Focus 1.6 (petrol), which has covered more than 85,000 miles. With a book time of just shy of five hours and basic workshop equipment required, this is a profitable repair for any worksh...