3584 PDF Files Listed

• 

• Technical Bulletin

• Mercedes Oil Filter Housing Cap with sealing ring Problem

• Nov 22

• Blue Print (202) Contact
• 

...Mercedes Oil Filter Housing Cap with sealing ring Problem Problem Whilst changing the engine oil filter during the service replacement process, the oil filter housing cap can break - leaving the oil filter alignment tube and element within the housing. (Fig.1) Cause After many hour...

• 

• Technical Bulletin

• Timing Chain Kit - Mitsubishi 4M41 Diesel Engine

• May 20

• Blue Print (202) Contact
• 

...iming Chain Kit - Mitsubishi 4M41 Diesel Engine Blue Print ADC47347, ADC47353 to fit: Mitsubishi Montero, Pajero and Shogun models fitted with 4M41 diesel engine Problem A rattling noise coming from the engine timing chain area or a broken timing chain. Cause The timing chain...

• 

• Technical Bulletin

• Hyundai/Kia Oxygen Sensor Problem

• Jun 22

• Blue Print (202) Contact
• 

...Problem The engine is running unevenly, fuel consumption has increased and the ‘check engine’ warning lamp is illuminated. Fault code P0141 - O2 sensor heater circuit (bank 1, sensor 2) malfunction is stored in the engine control unit (ECU). The fault re-appears after a new oxyg...

• 

• Technical Bulletin

• Kia/Hyundai Timing Belt Tensioner Installation

• Aug 20

• Blue Print (202) Contact
• 

...Kia Hyundai timing belt tensioner Problem This timing belt tensioner needs to be set correctly during the installation process. If this is not followed, this can cause the timing belt system to fail. Cause Removing the load pin too early influences the operation of the tensione...

• 

• Technical Bulletin

• Nissan Qashqai and X-Trail Fuel Filter Problem

• Mar 23

• Blue Print (202) Contact
• 

...To fit: Nissan Qashqai 2013 (J11) model, X-Trail 2014 (T32) Engine: K9K, R9M Problem The water in the fuel, lamp is illuminated on the vehicles dashboard display after the fuel filter has been replaced. Cause The incorrect filter has been fitted to the vehicle during servicin...

• 

• Technical Bulletin

• Hyundai i10 Clutch Cable Problem

• Jun 22

• Blue Print (202) Contact
• 

...To fit: RHD Hyundai i10 2007 2013 Blue Print ADBP380001 Hyundai i10 Clutch Cable Problem Problem The vehicle has difficulty engaging first or reverse gear, and has an inconsistent ‘biting point’ when depressing the clutch pedal. These issues can result in noise coming fr...

• 

• Technical Bulletin

• Brake Pad Failure in the Honda Civic with Electronic Parking Brake

• Mar 20

• Blue Print (202) Contact
• 

...PROTip - ADH242101 Brake Pad Failure in the Honda Civic with Electronic Parking Brake Problem Rear brake failure after replacement of the rear brake pads, or any other repair work involving removal of the rear brake caliper, resulting in the following. Over-extension of the rear bra...

• 

• Technical Bulletin

• Erratic Timing on Nissan Petrol Engines

• Mar 19

• Blue Print (202) Contact
• 

...Some Nissan petrol engines suffering from poor acceleration and erratic engine RPMs have Camshaft/Crankshaft timing issues that are from a loose timing chain. The models affected are Nissan Almera, Almera Tino, Expert, Micra, Note, Primera, Sunny, Wingroad with 1.0, 1.2, 1.4, 1.5, 1.6, 1.8...

• 

• Technical Bulletin

• Mitsubishi Colt and SMART Forfour Parking Brake Tempoarily Seized

• Feb 21

• Blue Print (202) Contact
• 

...Mitsubishi Colt and SMART Forfour Parking Brake Tempoarily Seized Problem After applying the parking brake the rear brake caliper becomes seized in operation, which could take 5-10 minutes to move freely again. This problem can affect either side separately or both sides together....

• 

• Technical Bulletin

• Clutch hydraulic circuit bleeding problem on Jeep/Chrysler

• May 23

• Blue Print (202) Contact
• 

...Blue Print Protips ADA103601, ADA103602, ADA103603, ADA103605, ADA103607, ADA103609, ADA103610 To fit: Jeep Cherokee, Grand Cherokee, Wrangler/Chrysler PT Cruiser, Neon, Voyager, Grand Voyager Clutch hydraulic circuit bleeding Problem Unable to purge the air from the clutch hy...