...LuK Clutch Academy Nissan Navara 2.5 DDTi REPXPERT Alistair Mason replaces the clutch and dual mass flywheel (DMF) on a Nissan Navara 2.5 DDTI, which had covered more than 103,000 miles. Following complaints of the clutch 'slipping', his assessment confirmed the cause, and a clutch and...
...LuK Clutch Academy Opel Meriva 1.4P REPXPERT Alistair Mason replaces the clutch on an Opel Meriva after the customer reported that the clutch was 'slipping'. Like other Opels, components are bolted to the subframe, which has to be lowered, so these helpful tips from LuK should help speed...
...LuK Clutch Academy2003 Mini One This month, REPXPERT Alistair Mason replaced the clutch on a 2003 Mini One, which had covered 103,000 miles. The customer reported that the clutch pedal was heavy when used. For this repair, a two-post vehicle lift, engine support, transmission jack and...
...LuK Clutch Academy Peugeot 206 1.1P This month, Alistair Mason, inspects a 2005 1.1 petrol Peugeot 206, which had covered more than 75,000 miles. It was difficult to get the vehicle into gear, as the clutch was not fully disengaging and there was a 'scrapping' noise emanating from the bel...
...LuK Clutch Academy Audi A1 1.6TDi This month, REPXPERT Alistair Mason, replaces the clutch on a 2016 Audi A1, fitted with a 1.6 TDi. With a repair time of just five hours and a requirement for only minimal workshop equipment – a two-post lift, engine support, transmission jack, clutch a...
...LuK Clutch Academy Ford Transit 2.2 TDCi FWD This month, REPXPERT Alistair Mason replaced the clutch on a 2011 Ford Transit 2.2 TDCI front-wheel drive, which had covered more than 130,000 miles. The repair time is just over three-and-three-quarter hours and requires a wheel-free vehicle...
...LuK Clutch Academy Nissan Qashqai 1.5 dCi This month, REPXPERT, Alistair Mason, replaced the clutch assembly in a 2014 2WD Nissan Qashqai. The repair time is four-and-a-half hours, with the following workshop equipment required: two-post vehicle lift, engine support, transmission jack...
...See this and 1,000s more Tech Tips on TechTips.ie 48 August/September 2020 AUTOBIZ See this and 1,000s more Tech Tips on TechTips.ie Gearbox removal With the vehicle positioned on a vehicle lift – either a two-post or wheel-free is ideal – open the bonnet, disconnect the ai...
...REPXPERT Alistair Mason, replaces the clutch on a Opel Movano 2.3 D, which had covered more than 140,000 miles. As is the norm with light commercial vehicles, the first job is to check the ramp's weight capability and how much equipment is in the back of the vehicle. The Movano has an '...
...LuK Clutch Academy 2009 Audi 2.0 TDI Quattro This month, REPXPERT Alistair Mason, replaced the clutch assembly and dual mass flywheel (DMF) on a 2009 Audi TT 2.0 TDi Quattro, which had covered more than 85,000 miles. With a recommended book time of seven hours and all information availabl...