Search 4,595 docs, articles & videos from the world’s leading Automotive part manufacturers
3646 PDF Files Listed
-
-
Technical Bulletin
- Belt Inspection Changes
-
Sep 15
- Gates (127) Contact
-
...AUTOMOTIVE PASSENGER CAR ACCESSORY BELT DRIVE SYSTEM Tech Tip Standard industry belt diagnostics call for replacement of a serpentine \ belt if it shows three cracks in a three inch section. This is a good rule of thumb for Neoprene, but not so good for EPDM. EPDM belts inherently resis...
-
-
Technical Bulletin
- Pulley Alignment & Tension
-
Sep 15
- Gates (127) Contact
-
...BULLETIN TT003-15› MAKE: All makes with a serpentine belt› MODEL: All models with a serpentine belt› YEAR: All years with a serpentine belt› ENGINE: All engines with a serpentine belt PULLEY ALIGNMENT & TENSIONToda...
-
-
Technical Bulletin
- Diagnosing Tensioner Failure
-
Sep 15
- Gates (127) Contact
-
...Unbeknownst to many, automatic belt tensioners are actually a wear item, and therefore cannot be classified as a prototypical hard part. Internal components in the tensioner can fail, causing stress on the belt and other accessory components. A tensioner is a relatively inexpensive part to...
-
-
Technical Bulletin
- Water Pump Failure Signs
-
Sep 15
- Gates (127) Contact
-
...If during the course of an inspection the water pump is found to look like any of the below, Gates recommends properly flushing the system, filling the system with a new mixture of the correct coolant, and possibly replacing the water pump depending on the issues found.BULLETIN TT005-15›...
-
-
Technical Bulletin
- Opel Insignia - Driver Information Centre shows "Code 55" or "Check DPF"
-
Sep 15
- Hella Ireland (1757)
-
...Opel Insignia Model year: from 2009 onwards Engine code: A20DTC / A20DTH / A20DTJ Driver Information Centre shows "Code 55" or check "DPF" "Code 55" or check "DPF" appears in the Driver Information Centre. At the same time, noises originate from the exhaust gas system and the engine...
-
-
Technical Bulletin
- Opel Astra H - Headlamp replacement
-
Sep 15
- Hella Ireland (1757)
-
...2015 Opel Astra H From model year 2004 With dynamic bend lighting "Dynabeam" Replacement of the light source If the light source has to be replaced in the vehicle specified above, proceed as follows: disassemble the front apron of the vehicle and remove the headlamp. Then replace th...
-
-
Technical Bulletin
- Opel Astra J - Charge signal lamp flashes
-
Sep 15
- Hella Ireland (1757)
-
...Opel Astra J Model year: from 2012 onwards Chassis no.: WLOPD6EB2CG000351 – WLOPD8ED5C8000092 – WLOPD6EB0C1000612 – Charge signal lamp flashes A complaint has ben made that the charge signal lamp flashes in the vehicles specifie...
-
-
Technical Bulletin
- VW Crafter - Battery discharges with ignition off (phantom load)
-
Sep 15
- Hella Ireland (1757)
-
...VW Crafter Model year: CW 40/2012 – 01/2013 Chassis no: WV1ZZZ2EZD6018306 – 25318 WV1ZZZ2FZD7002896 – 4666 Power consumption with the ignition switched off. The battery discharges. If the battery of the vehicles specified above discharges after the vehicl...
-
-
Technical Bulletin
- Opel Astra J - Charge signal lamp flashes
-
Sep 15
- Hella Ireland (1757)
-
...Opel Astra J Model year: from 2012 onwards Chassis no.: WLOPD6EB2CG000351 – WLOPD8ED5C8000092 – WLOPD6EB0C1000612 – Charge signal lamp flashes A complaint has ben made that the charge signal lamp flashes in the vehicles specifie...
-
-
Tech Tip
- Fiat Ducato 2.3D timing belt guide
-
Sep 15
- Dayco (52)
-
...Fiat Ducato 2.3D timing belt guide The 2.3-litre diesel engine is used in the popular Fiat Ducato since 2002 and equivalent Iveco Daily from 1999. Dayco recommend that all the systems' components - timing drive and auxiliary drive - be replaced at the same time. This step-by-step technic...
